掛墻板是以輕質陶粒作混凝土骨料。陶粒由于內部多孔，故具有良好的保溫隔熱性，用它配制的混凝土熱導率一般為0.3~0.8W、(m.k)它比普通混凝土底1~2倍。所以，陶粒建筑都有良好的隔熱環境，耐火性好，其耐火性是普通混凝土的四倍多。85mm墻板防火≥2.0小時、100mm墻板防火≥ 3.0小時。

Wall panels are made of lightweight ceramic particles as concrete aggregates. Due to its porous interior, ceramic particles have good thermal insulation properties. The thermal conductivity of concrete prepared with them is generally 0.3-0.8W, (m.k), which is 1-2 times higher than that of ordinary concrete. So, ceramic buildings have a good thermal insulation environment, good fire resistance, and their fire resistance is more than four times that of ordinary concrete. 85mm wall panels have a fire resistance of ≥ 2.0 hours, and 100mm wall panels have a fire resistance of ≥ 3.0 hours.

掛墻板屬于輕質骨料鋼筋混凝土產品，板材自身具備防水、防潮性能，可用于廚房、衛生間、地下室等潮濕區域且不會出現因吸潮而松化、反鹵、變形、強度下降等現象。試驗證明，墻板能在無任何飾面的情況下，用水泥粘結的 池體裝滿水后，墻板背面能保持干燥不留任何痕跡，在潮濕天氣里墻面也不會出現冷凝水珠，而一般砌體不能防潮，時間久了會產生批蕩層脫離現象。

Wall hanging panels belong to lightweight aggregate reinforced concrete products. The panels themselves have waterproof and moisture-proof properties, and can be used in damp areas such as kitchens, bathrooms, and basements without loosening, anti halogenation, deformation, and strength reduction due to moisture absorption. Experiments have shown that wall panels can be filled with water in a cement bonded pool without any surface finish. The back of the wall panel can remain dry without leaving any traces, and there will be no condensation water droplets on the wall even in humid weather. Generally, masonry cannot be moisture-proof, and over time, it may cause detachment of the batch layer.

墻板的榫接設計采用無收縮砂漿堵塞連接縫，并用高強纖維網帶于兩面覆蓋板縫， 因此墻身整體具有良好的防水、 防潮性。

The mortise and tenon joint design of the wall panel adopts non shrinkage mortar to block the connection joints, and high-strength fiber mesh tape is used to cover the board joints on both sides, so the overall wall body has good waterproof and moisture-proof properties.

面向浴室的墻板，于表面涂?jī)蓪铀苑莱眲┘霸诎鍔A縫填10mm 深的防水膠，可達到防潮要求。

The wall panel facing the bathroom can be coated with two layers of water-based moisture-proof agent on the surface and filled with 10mm deep waterproof adhesive in the gaps between the panels to meet the moisture-proof requirements.

掛墻板出色的隔音性能， 85mm墻板空氣聲計權隔音量達到47dB； 100mm墻板空氣聲計權隔音量達到51dB；可根據客戶的需求，通過特殊設計，生產隔音量達到50~53dB的墻板。

Excellent sound insulation performance of wall panels, with an air sound meter weight of 47dB for 85mm wall panels; 100mm wall panel air sound meter with a weighted sound insulation volume of 51dB; We can produce wall panels with a sound insulation capacity of 50-53dB according to customer needs through special design.

掛墻板可塑性強掛墻板是內配冷拔鋼筋網架，市面上罕見的雙面、雙向配筋輕質混凝土板材。

Wall hanging panels have strong plasticity. Wall hanging panels are rare lightweight concrete panels with double-sided and bi-directional reinforcement, which are equipped with cold drawn steel mesh frames.

在施工現場可根據要求任意開洞、切割、回填，而不影響墻板結構穩定性；   且內有貫通圓孔，方便水電管線的安裝隱埋。

At the construction site, holes can be opened, cut, and backfilled as required without affecting the stability of the wall panel structure; And there are through circular holes inside, which facilitate the installation and burial of water and electricity pipelines.

掛墻板板不含對人體有害物質，滿足國家標準GB6566-2001《建筑材料放射性核素*》標準，使用范圍不受任何限制，為國家部門認證的綠色環保建材。

Wall mounted panels do not contain harmful substances to the human body and meet the national standard GB6566-2001 "Radionuclides in Building Materials". The scope of use is not restricted, and they are certified as green and environmentally friendly building materials by national departments.

掛墻板的任何一點都可用錨固螺絲安裝櫥柜，亦可釘，及外掛大理石，吊掛力達到300Kg。

Anchor screws can be used to install cabinets at any point of the wall panel, nails can also be used, and marble can be hung externally, with a hanging force of up to 300Kg.

其它板材往往因芯孔太大，或板材剛度不足，無法提供足夠的錨固力，不能任意吊掛重物，給用戶帶來麻煩和不便。 根據英標BS5234做懸掛測試，懸掛力達到300Kg，錨固件保持原位，無松動或脫落。

Other boards often cannot provide sufficient anchoring force due to their large core holes or insufficient stiffness, and cannot freely hang heavy objects, causing inconvenience and inconvenience to users. According to the British standard BS5234, a suspension test was conducted, and the suspension force reached 300Kg. The anchor components remained in place without any looseness or detachment.

掛墻板采用機械錨固方式分別與結構墻、柱相連接，加上內配有鋼筋架，保證墻體具有良好的整體性，抗震、抗沖擊、抗彎折等性能是其它墻體無法相比的。根據BS5234做墻身擠壓試驗，在墻1.2m高處加載，荷載由零增長2.0KN、m，撓度變形＜1.0mm卸載后墻身恢復原形，無危險性破壞。

The hanging wall panels are connected to the structural walls and columns using mechanical anchoring methods, and are equipped with steel reinforcement frames to ensure that the walls have good integrity. Their seismic, impact, and bending resistance are unmatched by other walls. According to BS5234, a wall compression test was conducted, and the load was loaded at a height of 1.2m on the wall. The load increased by 2.0KN and m from zero, and the deflection deformation was less than 1.0mm. After unloading, the wall was restored to its original shape without any dangerous damage.

本文來自：富美家抗倍特更多的內容請點擊：http://www.intercoil.com.cn我們將會為您提問的問題提供一個滿意的服務，歡迎您的來

This article is from: Fumeijia Anti Betide. For more information, please click: http://www.intercoil.com.cn We will provide you with a satisfactory service for the questions you ask. Welcome to come